米曲霉固态发酵苏麻饼粕产抗氧化肽工艺优化

1. 贵州大学酿酒与食品工程学院, 贵州贵阳 550025;
2. 贵州省农业科学院油菜研究所, 贵州贵阳 550008

作者简介:龙久铃(1995-),女,贵州省黔东南苗族侗族自治州人,贵州大学硕士研究生,主要研究方向为功能性食品.;

基金项目:贵州省科技计划项目（黔科合成果（2018）4304）；贵州省生态特色肉制品科技创新人才团队项目（黔科合平台人才（2020）5004）；贵州省高层次创新型人才培养计划项目（黔科合平台人才（2016）5662）
中图分类号:TS209

Optimization of the process of producing antioxidant peptides fromAspergillus oryzaesolid-state fermentationPerillaseed meal

1. School of Liquor and Food Engineering, Guizhou University, Guiyang 550025, China;
2. Rapeseed Research Institute, Guizhou Academy of Agricultural Sciences, Guiyang 550008, China
Received Date:2021-03-04

CLC number:TS209

摘要:利用米曲霉固态发酵苏麻饼粕制备抗氧化肽粗提物，以其多肽含量和1，1-二苯基-2-三硝基苯肼（DPPH）自由基清除率为指标，对影响米曲霉固态发酵苏麻饼粕的发酵时间、发酵温度、接种量、液料比4个因素进行单因素试验，并在此基础上进行响应面优化.结果表明，米曲霉固态发酵苏麻饼粕的最佳工艺条件为发酵时间48 h，发酵温度28℃，接种量5.5%，液料比1∶1，该工艺条件下，苏麻饼粕抗氧化肽粗提物的多肽含量为（58.75±1.12） mg/g，比发酵前增加了2.66倍，DPPH自由基清除率为（82.13±1.54）%，比发酵前增加了0.23倍，DPPH自由基 IC ₅₀为0.17 mg/mL，即苏麻饼粕经米曲霉固态发酵后能获得抗氧化能力较高的生物活性肽.
- 苏麻饼粕/
- 米曲霉/
- 固态发酵/
- 抗氧化肽
Abstract:Aspergillus oryzae was used to prepare antioxidant peptides crude extract from Perilla seed meal by solid-state fermentation. The polypeptide content and 1, 1-diphenyl-2-trinitrophenylhydrazyl (DPPH) free radical scavenging rate were used as indicators, the single factor experiment was conducted on four factors that affect the fermentation time, fermentation temperature, inoculum amount, and liquid-to-material ratio of Aspergillus oryzae fermented Perilla seed meal, and the response surface was optimized on the basis of it. The results showed that the best process parameters for solid-state fermentation of Perilla seed meal by Aspergillus oryzae were fermentation time 48 h, fermentation temperature 28℃, inoculation amount 5.5% and liquid-to-material ratio 1:1. Under this technological condition, the polypeptide content of the solid-state fermentation product of Perilla seed meal was (58.75±1.12) mg/g, which was 2.66 times higher than that before fermentation; the DPPH free radical scavenging rate was (82.13±1.54)%, which was 0.23 times higher than that before fermentation; the IC50 of DPPH free radical was 0.17 mg/mL. The studies showed that Perilla seed meal could obtain biologically active peptides with high antioxidant capacity after solid-state fermentation of Aspergillus oryzae.
- Perillaseed meal/
- Aspergillus oryzae/
- solid-state fermentation/
- antioxidant peptides
1. [1]
  罗霞,陶金,危克周,等.唇形科植物:苏麻和紫苏亲缘关系鉴定[J].山地农业生物学报, 2014,33(5):28.
2. [2]
  SONG T,LIU L.A strategy for quality control of the fruits of Perilla frutescens (L.) Britt based on antioxidant activity and fingerprint analysis[J].Analytical Methods, 2015,8(2):232.
3. [3]
  潘艳,陈海玲,金铭,等.辣蓼草和紫苏粕面包的研制[J].食品研究与开发, 2015,36(15):42.
4. [4]
  郝磊,郝学财,邓莉,等.复合酶协同发酵紫苏粕制备天然调味料的研究[J].中国调味品, 2017,42(10):119.
5. [5]
  李荣,于君,姜子涛,等.微波辅助分步酶解紫苏饼粕蛋白制备鲜味肽[J].食品科学, 2017,38(20):169.
6. [6]
  徐世涛,朱秋劲,熊延敏,等.单-双酶法提取的苏麻多肽的呈味及氨基酸分析[J].食品与发酵工业, 2020,46(3):235.
7. [7]
  盛彩虹,李思朦,刘晔,等.紫苏肽制备工艺研究[J].中国油脂, 2011,36(10):20.
8. [8]
  YANG J J,HU L,CAI T T,et al.Purification and identification of two novel antioxidant peptides from perilla (Perilla frutescens L. Britton) seed protein hydrolysates[J].PLOS ONE, 2018,13(7):e0200021.
9. [9]
  PARK B Y,YOON K Y.Conditions for hydrolysis of perilla seed meal protein for producing hydrolysates and ultrafiltered peptides and their antioxidant activity[J].Korean Journal of Food Preservation, 2018,25(5):605.
10. [10]
  AMADOU I,LE G W,SHI Y H.Evaluation of antimicrobial, antioxidant activities, and nutritional values of fermented foxtail millet extracts by Lactobacillus paracasei Fn032[J].International Journal of Food Properties,2013,16(6):1179.
11. [11]
  彭惠惠,李吕木,钱坤,等.发酵芝麻粕中芝麻小肽的分离纯化及其体外抗氧化活性[J].食品科学, 2013,34(9):66.
12. [12]
  胡磊,陈艺宾,王惠敏,等.紫苏籽抗氧化肽的制备工艺研究[J].福州大学学报(自然科学版), 2017,45(5):742.
13. [13]
  ROSSANA C,GIUSEPPE R C,DANIELA P,et al.Selected lactic acid bacteria synthesize antioxidant peptides during sourdough fermentation of cereal flours[J].Applied and Environmental Microbiology, 2012,78(4):1087.
14. [14]
  武万兴,陈朝银,赵声兰,等.固态发酵核桃粕制备活性肽及其抗氧化活性的研究[J].食品工业科技, 2013,34(16):266.
15. [15]
  黄永锋,宋俊梅,卫琳.米曲霉固态发酵豆粕生产大豆肽[J].粮食加工,2009,34(6):51.
16. [16]
  TE B R, BOUSSIER A, VAN B N, et al. Identification of secreted proteins of Aspergillus oryzae associated with growth on solid sereal substrates[J].Journal of Biotechnology,2006,121(4):482.
17. [17]
  秦卫东,陈学红,马利华,等.黑曲霉发酵豆粕制备抗氧化肽研究[J].食品科学,2010,31(23):289.
18. [18]
  CHEN N,YANG H M,SUN Y,et al.Purification and identification of antioxidant peptides from walnut (Juglans regia L.) protein hydrolysates[J].Peptides, 2012,38(2):344.
19. [19]
  WU W X,ZHAO S L,CHEN C Y,et al.Optimization of production conditions for antioxidant peptides from walnut protein meal using solid-state fermentation[J].Food Science and Biotechnology, 2014,23(6):1941.
20. [20]
  GHOSH A,DAS P,SINHA K.Modeling of biosorption of Cu(Ⅱ) by alkali-modified spent tea leaves using response surface methodology (RSM) and artificial neural network (ANN)[J].Applied Water Science, 2015,5(2):191.
21. [21]
  鲁伟,任国谱,宋俊梅.蛋白水解液中多肽含量的测定方法[J].食品科学, 2005(7):169.
22. [22]
  HE R,JU X R,YUAN J,et al.Antioxidant activities of rapeseed peptides produced by solid state fermentation[J].Food Research International, 2012,49(1):432.
23. [23]
  邢瀚文,韩玮,施文正,等.固态发酵法制备罗非鱼皮胶原蛋白肽及其抗氧化活性研究[J].食品与发酵工业, 2020,46(19):104.
24. [24]
  王海燕,张凤兰,曹亚兰,等.米曲霉固态发酵结合成曲水解法制备大豆抗氧化肽的研究[J].现代食品科技, 2012,28(8):969.
1. [1]
  薛云,宁振兴,苏赞,刘启斌,王敏,毛多斌,龙章德,魏涛. 基于芽孢杆菌固态发酵技术提高广西河池C4F烟叶品质的研究. 轻工学报, 2022, 37(5): 76-84.doi: 10.12187/2022.05.009
2. [2]
  宋丽丽,霍姗浩,胡冉冉,赵鑫淼,朱钰琪,杨旭,张志平,魏涛. 复合乳酸菌固态发酵对脱脂米糠理化性质、生物活性和功能特性的影响. 轻工学报, 2024, 39(3): 21-28.doi: 10.12187/2024.03.003
3. [3]
  许春平,孙懿岩,姜宇,刘鸿,邹克兴,苏赞,孙建生,李季刚,杨龙彦,龙章德. 芽孢杆菌生物制剂对复烤后烟叶化学成分的影响. 轻工学报, 2019, 34(3): 34-41.doi: 10.3969/j.issn.2096-1553.2019.03.004
4. [4]
  章银良,周文权,郑坚强,吴琳琳,闫明. 超声波辅助萃取黑米中的花色苷及其抗氧化性的研究. 轻工学报, 2013, 28(1): 16-19,29.doi: 10.3969/j.issn.2095-476X.2013.01.004
5. [5]
  刘琨毅,王利妍,安江珊,罗慧,王兴华,马燕,吕才有,赵明. 阿曲霉接菌发酵普洱茶的研究. 轻工学报, 2022, 37(4): 1-9.doi: 10.12187/2022.04.001
6. [6]
  张菡,陈海军,龙晓宇,赵抒娜,魏学军,魏国坤,申光辉. 1株甜菜糖蜜源高产胞外多糖明串珠菌的分离鉴定、发酵工艺优化及抗氧化活性研究. 轻工学报, 2024, 39(3): 9-20.doi: 10.12187/2024.03.002
7. [7]
  李迎秋,郝曼,崔凯宇,孙秀秀. 大豆球蛋白碱性肽对黑曲霉和青霉的抑制效果研究. 轻工学报, 2016, 31(3): 33-38.doi: 10.3969/j.issn.2096-1553.2016.3.005
8. [8]
  杨旭,魏涛,张志平,宋丽丽,王光路,马歌丽. 强化微生物固态厌氧发酵对烟梗细胞壁组分的影响研究. 轻工学报, 2020, 35(6): 35-40.doi: 10.12187/2020.06.005
9. [9]
  李松林,林静,蒋长兴,陈晓明,王小花,叶华,王辉. 枸杞多肽的制备及其抗氧化活性研究. 轻工学报, 2016, 31(6): 31-37.doi: 10.3969/j.issn.2096-1553.2016.6.005
10. [10]
  高超. 款冬叶黄酮的抗氧化活性研究. 轻工学报, 2020, 35(2): 17-23.doi: 10.12187/2020.02.003
11. [11]
  张明君,李迎秋. 牡丹籽酱油的制备及其抗氧化活性研究. 轻工学报, 2023, 38(4): 53-60.doi: 10.12187/2023.04.007
12. [12]
  章银良,章馨元,张陆燕,卢慢慢,时国庆. 甲醇体系中美拉德反应产物抗氧化活性的研究. 轻工学报, 2014, 29(4): 20-23,28.doi: 10.3969/j.issn.2095-476X.2014.04.005
13. [13]
  张煜,张晓娜,薛桥丽,肖蓉,林奇,胡永金. 扁枝槲寄生提取物体外抗氧化效应研究. 轻工学报, 2016, 31(3): 39-48.doi: 10.3969/j.issn.2096-1553.2016.3.006
14. [14]
  刘瑞山,梁治军,周文权,齐强强. 均匀试验优化黑蒜提取液的抗氧化活性. 轻工学报, 2014, 29(2): 15-18.doi: 10.3969/j.issn.2095-476X.2014.02.005
15. [15]
  刘晓丽,郭曹羽,林锴立,廖文莹,王文燕. 壳聚糖基抑菌抗氧化活性复合膜的制备及其性能研究. 轻工学报, 2023, 38(4): 27-36.doi: 10.12187/2023.04.004
16. [16]
  庄姗姗,刘袆帆,张沁铭,肖更生,戴宏杰,马路凯. 柚子幼果精油的提取及其抗氧化活性研究. 轻工学报, 2022, 37(2): 51-58.doi: 10.12187/2022.02.007
17. [17]
  章银良,庞丹洋,卢慢慢,蔡亚玲. 金属离子对鲫鱼蛋白-D-木糖美拉德反应产物抗氧化活性的影响. 轻工学报, 2017, 32(1): 7-12.doi: 10.3969/j.issn.2096-1553.2017.1.002
18. [18]
  许春平,姜宇,曾颖,马扩彦,谭兰兰,申屠洪钎,曲利利,孟丹丹,戴亚. 不同酶解条件对烟叶蛋白水解度和抗氧化性的影响. 轻工学报, 2017, 32(6): 56-62.doi: 10.3969/j.issn.2096-1553.2017.6.007
19. [19]
  章银良,卢慢慢,章馨元,张陆燕,庞丹洋. 不同反应溶剂对鲫鱼蛋白-D-木糖体系美拉德反应产物抗氧化活性的影响. 轻工学报, 2015, 30(5-6): 22-26,32.doi: 10.3969/j.issn.2095-476X.2015.5/6.005
20. [20]
  赵甜甜,张国治,王赵改,蒋鹏飞. 两种市售香椿茶主要活性成分、抗氧化活性及挥发性成分的对比分析. 轻工学报, 2023, 38(3): 35-45.doi: 10.12187/2023.03.005

点击查看大图

计量

PDF下载量:18
文章访问数:1159
引证文献数:0

通讯作者:陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

米曲霉固态发酵苏麻饼粕产抗氧化肽工艺优化

作者简介:龙久铃(1995-),女,贵州省黔东南苗族侗族自治州人,贵州大学硕士研究生,主要研究方向为功能性食品.;

Optimization of the process of producing antioxidant peptides fromAspergillus oryzaesolid-state fermentationPerillaseed meal

计量

通讯作者:陈斌, bchen63@163.com

米曲霉固态发酵苏麻饼粕产抗氧化肽工艺优化

作者简介:龙久铃(1995-),女,贵州省黔东南苗族侗族自治州人,贵州大学硕士研究生,主要研究方向为功能性食品.

English Abstract

Optimization of the process of producing antioxidant peptides fromAspergillus oryzaesolid-state fermentationPerillaseed meal

目录

米曲霉固态发酵苏麻饼粕产抗氧化肽工艺优化

作者简介:龙久铃(1995-),女,贵州省黔东南苗族侗族自治州人,贵州大学硕士研究生,主要研究方向为功能性食品.;

Optimization of the process of producing antioxidant peptides fromAspergillus oryzaesolid-state fermentationPerillaseed meal

计量

文章相关

通讯作者:陈斌, bchen63@163.com

米曲霉固态发酵苏麻饼粕产抗氧化肽工艺优化

作者简介:龙久铃(1995-),女,贵州省黔东南苗族侗族自治州人,贵州大学硕士研究生,主要研究方向为功能性食品.

English Abstract

Optimization of the process of producing antioxidant peptides fromAspergillus oryzaesolid-state fermentationPerillaseed meal

目录