通风分配对细支卷烟主流烟气有机酸释放量的影响研究 - 18新利直播

CN 41-1437/TS ISSN 2096-1553

通风分配对细支卷烟主流烟气有机酸释放量的影响研究

王冰,岳保山,彭斌,杨松,刘绍峰,余晶晶,余振华,蔡君兰

王冰, 岳保山, 彭斌, 等. 通风分配对细支卷烟主流烟气有机酸释放量的影响研究[J]. 轻工学报, 2021, 36(4): 37-44. doi: 10.12187/2021.04.005

引用本文:王冰, 岳保山, 彭斌, 等. 通风分配对细支卷烟主流烟气有机酸释放量的影响研究[J]. 轻工学报, 2021, 36(4): 37-44.doi:10.12187/2021.04.005

WANG Bing, YUE Baoshan, PENG Bin, et al. Study on effect of ventilation distribution on the release of organic acids of slim cigarette mainstream smoke[J]. Journal of Light Industry, 2021, 36(4): 37-44. doi: 10.12187/2021.04.005

Citation:WANG Bing, YUE Baoshan, PENG Bin, et al. Study on effect of ventilation distribution on the release of organic acids of slim cigarette mainstream smoke[J]. Journal of Light Industry, 2021, 36(4): 37-44.doi:10.12187/2021.04.005

通风分配对细支卷烟主流烟气有机酸释放量的影响研究

1. 中国烟草总公司郑州烟草研究院, 河南郑州 450001;
2. 云南中烟工业有限责任公司技术中心, 云南昆明 650000

作者简介:王冰(1979-),女,河南省郑州市人,中国烟草总公司高级工程师,主要研究方向为烟草有害成分及香味成分.;

基金项目:中国烟草总公司重点实验室项目（110201603006）；云南中烟工业有限责任公司郑州烟草研究院联创平台项目（D2018199）
中图分类号:TS411.2

Study on effect of ventilation distribution on the release of organic acids of slim cigarette mainstream smoke

1. Zhengzhou Tobacco Research Institute of CNTC, Zhengzhou 450001, China;
2. Technology Center, China Tobacco Yunnan Industrial Co., Ltd., Kunming 650000, China
Received Date:2021-04-06

CLC number:TS411.2

摘要:为考查不同通风分配对细支卷烟主流烟气有机酸释放量的影响，卷制具有不同滤嘴通风率和卷烟纸透气度的细支卷烟样品，利用GC-MS法分析所制样品烟气中的有机酸种类，并建立基于滤嘴通风率、卷烟纸通风率的有机酸释放量预测模型.结果表明：1）共检测出26种有机酸，随着滤嘴通风率或卷烟纸通风率的增加，分子量较小的有机酸降低率较高，而分子量较大的有机酸降低率较低，卷烟纸通风率对烟气中有机酸释放量的影响大于滤嘴通风率；2）在总通风率一定时，高滤嘴通风率搭配低卷烟纸通风率设计的卷烟烟气中有机酸释放量比低滤嘴通风率搭配高卷烟纸通风率的更高；3）所建有机酸释放量预测模型准确度较高，预测结果进一步证明高滤嘴通风率搭配低卷烟纸通风率设计的卷烟有机酸释放量更高.
- 细支卷烟/
- 通风分配/
- 主流烟气/
- 有机酸
Abstract:In order to investigate the effect of different ventilation distribution on organic acid release from mainstream smoke of slim cigarette, the slim cigarette samples with different filter ventilation and cigarette paper air permeability were rolled, and the organic acid in mainstream smoke of samples were analyzed by GC-MS, the prediction models of organic acids release based on both filter and paper ventilation rate were established. The results showed that were as follows:26 kinds of organic acids were detected. With the increase of filter ventilation rate or paper ventilation rate, the decrease rate of organic acids with smaller molecular weight was higher, while that with larger molecular weight was smaller, and the effect of paper ventilation rate on the release of organic acids in cigarette smoke was greater than that of filter ventilation rate. When the total ventilation rate(V) was constant, the release of organic acids in cigarette smoke with high filter ventilation rate and low paper ventilation rate was higher than that with low filter ventilation rate and high paper ventilation rate. The prediction accuracy of the model of organic acid release was high, and the results further proved that the cigarette organic acid release was higher with the combination of high filter ventilation rate and low paper ventilation rate.
- slim cigarette/
- ventilation distribution/
- mainstream smoke/
- organic acid
1. [1]
  MUTTI S,HAMMOND D,BORLAND R,et al.Beyond light and mild:cigarette brand descriptors and perceptionsof risk in the International Tobacco Control (ITC) Four Country Survey[J].Addiction,2011,106(6):1166.
2. [2]
  FORD A,MOODIE C,MACKINTOSH A M,et al.Adolescent perceptions of cigarette appearance[J].European Journal of Public Health,2014,24(3):464.
3. [3]
  SIU M,MLADJENOVIC N,SOO E.The analysis of mainstream smoke emissions of Canadian ‘super slim’ cigarettes[J].Tobacco Control,2013,22(6):e10.
4. [4]
  DENG N,WANG Y L,CUI X M,et al.Effects of varying tobacco rod circumference on cigarette combustion:an experimental investigation[J].Beitraege zur Tabakforschung International,2019,28(6):286.
5. [5]
  KEVIN M A,ALISON E,IAN M,et al. Influence of cigarette circumference on smoke chemistry, biological activity, and smoking behaviour[J].Regulatory Toxicology and Pharmacology, 2016,82:111.
6. [6]
  朱先约,谢玉龙,崔迟,等.基于味觉活力值的通风卷烟酸味变化分析[J].烟草科技, 2019,52(11):50.
7. [7]
  潘立宁,王冰,刘绍锋,等.辅助材料参数对卷烟主流烟气中酸性香味成分释放量的影响[J].烟草科技,2014(3):46.
8. [8]
  谢玉龙,朱先约,蔡君兰,等.滤嘴通风对卷烟烟气有机酸的影响[J].烟草科技, 2018, 51(3):30.
9. [9]
  葛畅,赵明月,胡有持,等.细支与常规卷烟主流烟气常规指标及中性致香成分对比分析[J].烟草科技,2017,50(4):43.
10. [10]
  周全,银董红,文建辉,等.卷烟纸参数对细支卷烟主流烟气常规化学成分和香味成分释放量的影响[J].烟草科技, 2018, 51(8):61.
11. [11]
  楚文娟,田海英,冯晓民,等.滤嘴参数对细支烟主流烟气中5种关键烤甜香释放量的影响[J].轻工学报, 2019,34(1):43.
12. [12]
  杨松,岳保山,孙培健,等.通风对细支烟主流烟气常规成分及7种有害成分释放量的影响[J].烟草科技, 2020,53(12):37.
13. [13]
  余晶晶,赵晓东,王冰,等.不同透气度卷烟主流烟气中香味成分的逐口递送规律研究[J].轻工学报, 2019,34(3):42.
14. [14]
  朱先约,崔迟,谢玉龙,等.滤嘴通风对卷烟主流烟气主要氮杂环类碱性香味成分释放量的影响[J].烟草科技,2019,52(8):52.
15. [15]
  中华人民共和国国家质量监督检验检疫总局.卷烟和滤棒物理性能的测定:GB/T 22838-2009[S].北京:中国标准出版社,2009.
16. [16]
  楚文娟,田海英,彭桂新,等.基于卷烟材料参数的细支烟烟气有害成分预测模型[J]. 烟草科技, 2019,52(9):46.
17. [17]
  王冰,余晶晶,蔡君兰,等.GC-MS/MS法同时分析烟叶中42种有机酸[J].烟草科技,2020,53(11):49.
18. [18]
  杨君,储国海,胡安福,等.卷烟纸透气度与克重对烟用香料在主流烟气中转移行为的影响[J].云南农业大学学报, 2013,28(2):230.
1. [1]
  郭华诚,胡仙妹,高尊华,李金周,王红霞. 针辊式烟丝结构调控设备参数变化对细支烟卷制品质的影响. 轻工学报, 2024, 39(2): 122-126.doi: 10.12187/2024.02.016
2. [2]
  杜赫,杨洪峰,吴爽爽,赵怡凡,董露,田野,王志刚,陈晨. 卷烟降焦减害滤棒构件的制备及应用. 轻工学报, 2024, 39(2): 94-99,121.doi: 10.12187/2024.02.012
3. [3]
  方亦成,杨菁,陆诚玮,冯奇,汪旭. 基于层次分析法的加热卷烟感官评价指标筛选及其权重建立. 轻工学报, 2024, 39(2): 107-113.doi: 10.12187/2024.02.014
4. [4]
  李跑,谭惠珍,谢叔娥,苏光林,董怡青,唐辉. 基于近红外光谱技术有监督模式识别的青皮产地溯源分析. 轻工学报, 2024, 39(2): 54-59.doi: 10.12187/2024.02.007
5. [5]
  田金虎,袁颖,卢昕博,汤晓东,潘力,王雨凝,叶兴乾,蒋健. 微波预处理对加热卷烟用烤烟烟叶常规化学成分及挥发性香气成分的影响. 轻工学报, 2024, 39(2): 69-79.doi: 10.12187/2024.02.009

WeChat

点击查看大图

计量

PDF下载量:35
文章访问数:2689
引证文献数:0

通讯作者:陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

王冰, 岳保山, 彭斌, 等. 通风分配对细支卷烟主流烟气有机酸释放量的影响研究[J]. 轻工学报, 2021, 36(4): 37-44. doi: 10.12187/2021.04.005

引用本文:王冰, 岳保山, 彭斌, 等. 通风分配对细支卷烟主流烟气有机酸释放量的影响研究[J]. 轻工学报, 2021, 36(4): 37-44.doi:10.12187/2021.04.005

WANG Bing, YUE Baoshan, PENG Bin, et al. Study on effect of ventilation distribution on the release of organic acids of slim cigarette mainstream smoke[J]. Journal of Light Industry, 2021, 36(4): 37-44. doi: 10.12187/2021.04.005

Citation:WANG Bing, YUE Baoshan, PENG Bin, et al. Study on effect of ventilation distribution on the release of organic acids of slim cigarette mainstream smoke[J]. Journal of Light Industry, 2021, 36(4): 37-44.doi:10.12187/2021.04.005

通风分配对细支卷烟主流烟气有机酸释放量的影响研究

作者简介:王冰(1979-),女,河南省郑州市人,中国烟草总公司高级工程师,主要研究方向为烟草有害成分及香味成分.

1. 中国烟草总公司郑州烟草研究院, 河南郑州 450001;
2. 云南中烟工业有限责任公司技术中心, 云南昆明 650000

收稿日期: 2021-04-06

基金项目:中国烟草总公司重点实验室项目（110201603006）；云南中烟工业有限责任公司郑州烟草研究院联创平台项目（D2018199）

关键词:

摘要:为考查不同通风分配对细支卷烟主流烟气有机酸释放量的影响，卷制具有不同滤嘴通风率和卷烟纸透气度的细支卷烟样品，利用GC-MS法分析所制样品烟气中的有机酸种类，并建立基于滤嘴通风率、卷烟纸通风率的有机酸释放量预测模型.结果表明：1）共检测出26种有机酸，随着滤嘴通风率或卷烟纸通风率的增加，分子量较小的有机酸降低率较高，而分子量较大的有机酸降低率较低，卷烟纸通风率对烟气中有机酸释放量的影响大于滤嘴通风率；2）在总通风率一定时，高滤嘴通风率搭配低卷烟纸通风率设计的卷烟烟气中有机酸释放量比低滤嘴通风率搭配高卷烟纸通风率的更高；3）所建有机酸释放量预测模型准确度较高，预测结果进一步证明高滤嘴通风率搭配低卷烟纸通风率设计的卷烟有机酸释放量更高.

English Abstract

参考文献 (18) 相关文章 (5)

/

下载: 全尺寸图片幻灯片

分享

用微信扫码二维码

分享至好友和朋友圈