挤压法复合焦甜香料的制备及卷烟应用研究 - 18新利直播

CN 41-1437/TS ISSN 2096-1553

挤压法复合焦甜香料的制备及卷烟应用研究

李天笑,蒋忠荣,贾玉红,施丰成,罗诚,李东亮

李天笑, 蒋忠荣, 贾玉红, 等. 挤压法复合焦甜香料的制备及卷烟应用研究[J]. 轻工学报, 2021, 36(4): 51-57. doi: 10.12187/2021.04.007

引用本文:李天笑, 蒋忠荣, 贾玉红, 等. 挤压法复合焦甜香料的制备及卷烟应用研究[J]. 轻工学报, 2021, 36(4): 51-57.doi:10.12187/2021.04.007

LI Tianxiao, JIANG Zhongrong, JIA Yuhong, et al. Study on the preparation and cigarette application of synergistic caramel products by extrusion method[J]. Journal of Light Industry, 2021, 36(4): 51-57. doi: 10.12187/2021.04.007

Citation:LI Tianxiao, JIANG Zhongrong, JIA Yuhong, et al. Study on the preparation and cigarette application of synergistic caramel products by extrusion method[J]. Journal of Light Industry, 2021, 36(4): 51-57.doi:10.12187/2021.04.007

挤压法复合焦甜香料的制备及卷烟应用研究

1. 四川中烟工业有限责任公司技术中心, 四川成都 610051;
2. 18新利直播食品与生物工程学院, 河南郑州 450001

作者简介:李天笑(1990-),男,河南省漯河市人,四川中烟工业有限责任公司博士后,18新利直播讲师,主要研究方向为烟草工程.;

基金项目:河南省高校科技创新团队支持计划项目（20IRTSTHN022）；四川中烟工业有限责任公司科技项目（hx201908）
中图分类号:TS41

Study on the preparation and cigarette application of synergistic caramel products by extrusion method

1. Technology Center, China Tobacco Sichuan Industrial Co., Ltd., Chengdu 610051, China;
2. College of Food and Bioengineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China
Received Date:2021-04-22

CLC number:TS41

摘要:为合理利用不适用烟叶，开发甜感明显、香味丰富的烟用焦甜香料，以焦糖化反应为基础，研发一种挤压法复合焦甜香料.采用单因素试验确定该复合焦甜香料的制备工艺，并利用GC-MS检测和感官评价分析该香料的香味成分和不同产地不适用烟叶制备工艺的适用性.结果表明：葡萄糖适宜添加质量分数为30%，比较合适适宜的挤压温度为三区170℃、二区150℃；与对照组相比，利用挤压法制备的复合香料焦甜香韵成分含量提升了4.4倍，烟草萜烯类本香成分含量也显著提高；复合焦甜香料能提升卷烟香味的丰富性，增加甜感，改善口感；该复合焦甜香料的制备工艺对不同产地的不适用烟叶有一定的适用性.
- 不适用烟叶/
- 焦糖化反应/
- 挤压法/
- 香味成分/
- GC-MS检测
Abstract:To make better use of discarded tobacco leaves and yield caramel spices for tobacco with obvious sweetness and rich fragrance, synergistic caramel products by extrusion method were developed on the basis of the caramel reactions. The single factor experiment was used to determine the preparation process of the synergistic caramel products. GC-MS detection and sensory evaluation were used to analyze the flavor components of the products and the applicability of discarded tobacco leaves for different producing areas the preparation process. The results show that the optimal mass fraction of glucose was 30%. The extrusion temperature of area Ⅲ 170℃ and area Ⅱ 150℃ was suitable. Compared with the control group, the aroma components content of the synergistic caramel products were increased by 4.4 folds, and the contents of tobacco terpenes fragrances were also significantly increased. The synergistic caramel products could improve the flavor richness, sweetness and taste of cigarette. The preparation method of the synergistic caramel products had certain applicability to the discarded tobacco leaves from different producing areas.
- discarded tobacco leave/
- caramel reaction/
- extrusion method/
- flavor compound/
- GC-MS detection
1. [1]
  CHAPPEL C I, HOWELL J C. Caramel colours:a historical introduction[J].Food & Chemical Toxicology, 1992, 30(5):351.
2. [2]
  GOLON A, KUHNERT N. Characterisation of "caramel-type" thermal decomposition products of selected monosaccharides including fructose, mannose, galactose,arabinose and ribose by advanced electrospray ionization mass spectrometry methods[J].Food & Function, 2013, 4(7):1040.
3. [3]
  杨伟.以葡萄糖和麦芽糖生产焦糖色素的工艺研究与性质对比[D].无锡:江南大学, 2008.
4. [4]
  李美玲, 王卓琳, 黎庆涛, 等.焦糖色素及其研究进展[J].中国调味品, 2019, 44(9):189.
5. [5]
  李祥, 苏秀霞, 吴桂霞, 等. 挤压法焦糖色素生产工艺研究[J]. 中国酿造, 2007,26(2):43.
6. [6]
  乐毅, 刘学文, 伍学明,等. 挤压法生产焦糖色素机理分析及试制产品考察[J]. 食品与发酵科技, 2010, 46(4):53.
7. [7]
  魏忠保, 代惠娟, 张鹏, 等.不适用烟叶在造纸法再造烟叶中的应用研究[J].造纸装备及材料, 2020, 49(5):70.
8. [8]
  ZHANG X Z, GAO H J, ZHANG L F, et al. Extraction of essential oil from discarded tobacco leaves by solvent extraction and steam distillation, and identification of its chemical composition[J]. Industrial Crops & Products, 2012, 39:162.
9. [9]
  雷声, 杨锡洪, 张玲,等.糖及糖衍生物在卷烟增香保润中的研究进展[J].农产品加工, 2016(12):44.
10. [10]
  米兰, 熊珍, 秦瑜, 等.工业不适用烟叶打叶复烤内在品质改善研究[J].湖北农业科学, 2016, 55(19):5144.
11. [11]
  ZHAO G H, YU Y L, ZHOU X T, et al. Effects of drying pretreatment and particle size adjustment on the composting process of discarded flue-cured tobacco leaves[J].Waste Management & Research, 2017, 35:534.
12. [12]
  LI T X, JI L B, JIANG Z R, et al. Caramel products of glucose with water during heating process and their bioactivities[J].International Journal of Food Properties, 2020, 23:978.
13. [13]
  LI T X, LUO C, GENG Z Z, et al. Type I caramel products of maltose and sucrose with water and their antioxidant activities[J/OL].Food Science and Technology, 2021.[2021-04-22].https://doi.org/10.1590/fst.58520.
14. [14]
  戴魁, 李诗平, 王文斌,等.模拟红薯烘烤制备焦甜香香料及其卷烟应用[J].烟草科技, 2015, 48(9):27-32
  , 44.
15. [15]
  许春平, 熊亚妹, 刘远上, 等.不同加热醇化时间对烟草薄片浓缩液香味成分的影响[J].轻工学报, 2021, 36(1):30.
16. [16]
  叶建斌, 吕丽文, 王璐,等.造纸法再造烟叶工艺流程中中性香味物质的变化[J]. 河南农业大学学报, 2019, 53(3):415.
1. [1]
  孟克迪,张国治,王赵改,史冠莹. 基于GC-IMS比较不同干燥方式对香椿挥发性成分的影响. 轻工学报, 2024, 0(0): -.
2. [2]
  苑彬,金慧,骈琳,高思今,黄泽华. 美拉德反应对食品品质与安全的影响及其产物检测研究进展. 轻工学报, 2024, 39(2): 60-68.doi: 10.12187/2024.02.008
3. [3]
  田金虎,袁颖,卢昕博,汤晓东,潘力,王雨凝,叶兴乾,蒋健. 微波预处理对加热卷烟用烤烟烟叶常规化学成分及挥发性香气成分的影响. 轻工学报, 2024, 39(2): 69-79.doi: 10.12187/2024.02.009
4. [4]
  方亦成,杨菁,陆诚玮,冯奇,汪旭. 基于层次分析法的加热卷烟感官评价指标筛选及其权重建立. 轻工学报, 2024, 0(0): -.
5. [5]
  方亦成,杨菁,陆诚玮,冯奇,汪旭. 基于层次分析法的加热卷烟感官评价指标筛选及其权重建立. 轻工学报, 2024, 39(2): 107-113.doi: 10.12187/2024.02.014
6. [6]
  吴澄宇,李迎秋. 韭花精油主成分对单增李斯特氏菌的抑菌活性和抑菌机理. 轻工学报, 2024, 0(0): -.
7. [7]
  吴澄宇,李迎秋. 韭花精油主成分对单增李斯特氏菌的抑菌活性和抑菌机理. 轻工学报, 2024, 39(2): 36-42.doi: 10.12187/2024.02.005
8. [8]
  楚文娟,樊文鹏,高子婷,韩路,田海英,姬小明,万纪强,来苗. 新型保润剂丙二醇吡咯酯的制备及其对再造烟叶保润效果研究. 轻工学报, 2024, 0(0): -.
9. [9]
  楚文娟,樊文鹏,高子婷,韩路,田海英,姬小明,万纪强,来苗. 新型保润剂丙二醇吡咯酯的制备及其对再造烟叶保润效果研究. 轻工学报, 2024, 39(2): 87-93.doi: 10.12187/2024.02.011
10. [10]
  何屹,杨本刚,尹嵩,陈实,尹晓东,周文忠,贾学伟,杨盼盼. 基于随机蛙跳筛选的初烤烟叶中β-胡萝卜素和叶黄素含量近红外模型的建立. 轻工学报, 2024, 39(2): 100-106.doi: 10.12187/2024.02.013

WeChat

点击查看大图

计量

PDF下载量:18
文章访问数:1268
引证文献数:0

通讯作者:陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

李天笑, 蒋忠荣, 贾玉红, 等. 挤压法复合焦甜香料的制备及卷烟应用研究[J]. 轻工学报, 2021, 36(4): 51-57. doi: 10.12187/2021.04.007

引用本文:李天笑, 蒋忠荣, 贾玉红, 等. 挤压法复合焦甜香料的制备及卷烟应用研究[J]. 轻工学报, 2021, 36(4): 51-57.doi:10.12187/2021.04.007

LI Tianxiao, JIANG Zhongrong, JIA Yuhong, et al. Study on the preparation and cigarette application of synergistic caramel products by extrusion method[J]. Journal of Light Industry, 2021, 36(4): 51-57. doi: 10.12187/2021.04.007

Citation:LI Tianxiao, JIANG Zhongrong, JIA Yuhong, et al. Study on the preparation and cigarette application of synergistic caramel products by extrusion method[J]. Journal of Light Industry, 2021, 36(4): 51-57.doi:10.12187/2021.04.007

挤压法复合焦甜香料的制备及卷烟应用研究

作者简介:李天笑(1990-),男,河南省漯河市人,四川中烟工业有限责任公司博士后,18新利直播讲师,主要研究方向为烟草工程.

1. 四川中烟工业有限责任公司技术中心, 四川成都 610051;
2. 18新利直播食品与生物工程学院, 河南郑州 450001

收稿日期: 2021-04-22

基金项目:河南省高校科技创新团队支持计划项目（20IRTSTHN022）；四川中烟工业有限责任公司科技项目（hx201908）

关键词:

摘要:为合理利用不适用烟叶，开发甜感明显、香味丰富的烟用焦甜香料，以焦糖化反应为基础，研发一种挤压法复合焦甜香料.采用单因素试验确定该复合焦甜香料的制备工艺，并利用GC-MS检测和感官评价分析该香料的香味成分和不同产地不适用烟叶制备工艺的适用性.结果表明：葡萄糖适宜添加质量分数为30%，比较合适适宜的挤压温度为三区170℃、二区150℃；与对照组相比，利用挤压法制备的复合香料焦甜香韵成分含量提升了4.4倍，烟草萜烯类本香成分含量也显著提高；复合焦甜香料能提升卷烟香味的丰富性，增加甜感，改善口感；该复合焦甜香料的制备工艺对不同产地的不适用烟叶有一定的适用性.

English Abstract

参考文献 (16) 相关文章 (10)

/

下载: 全尺寸图片幻灯片

分享

用微信扫码二维码

分享至好友和朋友圈